USE OF QUARRY WASTE AS BUILDING MATERIAL: A …

III. USE OF QUARRY WASTE IN BRICKS (Shakir et al., 2013) use quarry dust for construction of clay bricks. For this study, three wastei.e., fly ash, quarry dust,and billet scale was used for theconstruction of clay bricks. The cement and quarry dust was first dry mixed for 2 minutes and then billet scale and fly ash were added in various proportion,

ASSESSING STRENGTH AND DURABILITY …

the optimal FA percentages to improve burnt clay bricks, benefiting the construction industry and promoting environment friendly brick production. Keywords: Compressive Strength, Fly Ash, Hyderabad Bricks, Mirupurkhas Bricks. I. INTRODUCTION Brick is a fundamental building construction material composed of clay or shale that has been …

Study on Strength and Durability of Concrete by Partial

The optimum ratio of billet scale and fly ash is found to be 1:1, billet scale and quarry dust is 1:1. It is indicated that the bricks developed in this study can be used as an alternative to ...

Quarry dust as river sand replacement in cement masonry …

The present study emphasizes the combined use of quarry waste ( substitute for river sand) and fly ash (0, 10, 20, 30 and 40% substitute for cement) for sustainable masonry block production. The physical, mechanical, and durability properties of cement blocks made using fly ash and quarry waste underwent a thorough investigation.

Waste Products as an Alternative Construction Material-A Review

The optimum ratio of billet scale and fly ash is found to be 1:1, billet scale and quarry dust is 1:1. It is indicated that the bricks developed in this study can be used as an alternative to ...

Professor & Head Of the Department

Alaa Shakir, Sivakumar N, Kamal Nasharuddin M. Properties of bricks made using fly ash, quarry dust and billet scale. Construction and building materials, 41 (2013) 131–138 (SCI). ... Performance of bricks …

Utilizing high volumes quarry wastes in the production of …

Dehwah [12] investigated the mechanical properties of SCC produced with quarry dust, silica fume plus quarry dust, or fly ash only. It was found that SCC incorporating 8–10% quarry dust possessed the similar mechanical properties as that of SCC prepared by using quarry dust plus silica fume or fly ash only.

Influence of Lime and Brick Dust on Compaction and

The optimum ratio of billet scale and fly ash is found to be 1:1, billet scale and quarry dust is 1:1. It is indicated that the bricks developed in this study can be used as an alternative to ...

Experimental Study on the Out-of-Plane Behavior of Brick …

In the past, fiber-reinforced polymer (FRP) composites have been extensively used to modify the structural response of masonry brick walls. The promising advantages of FRP composites are easy application, lightweight, and very high tensile strength. However, FRP composites are very expensive, and their availability is an issue, especially in …

Properties of bricks made using fly ash, quarry dust and billet …

This paper reports the findings of an investigation done on bricks made using fly ash (FA), quarry dust (QD), and billet scale (BS) by non conventional method.

Properties of bricks made using fly ash, quarry dust and billet …

This paper reports the findings of an investigation done on bricks made using fly ash (FA), quarry dust (QD), and billet scale (BS) by non conventional method. The procedure for …

[PDF] Experimental study of the firing of red clay bricks using

An experimental study of the firing of red brick using liquefied petroleum gas as fuel was performed in a fixed kiln. Improvement alternatives to the traditional firing techniques were analyzed, including the design of a thermally efficient kiln and the use of gas burners to reduce the pollution generated by using trash or other industrial or …

Performance of bricks made using fly ash and bottom ash

It is concluded that development of bricks using bottom ash and fly ash is feasible. Acknowledgement. ... Properties of bricks made using fly ash, quarry dust and billet scale, quarry dust and billet scale. Constr. Build. Mater., 41 (2013), pp. 131-138. View PDF View article View in Scopus Google Scholar [5]

DURABILITY PROPERTY OF FLY ASH, QUARRY DUST …

594 A. A. Shakir and A. A. Mohammed Journal of Engineering Science and Technology May 2015, Vol. 10(5) D as shown in Table 2. For series a, 15% of cement, 60% of quarry dust and 25% of fly ash and ...

Production of Ceramic Materials Using only Waste as Raw Materials

Influence of BFS Content in the Mechanical Properties and Acid Attack Resistance of Fly Ash Based Geopolymers ... Characteristics of acid resisteng bricks made from quarry residues and waste steel slag. Constr. Build. Mater., 22 (2008) 1887-1896. ... Properties of bricks made using fly ash, quarry dust and billet scale. Constr. Build. Mater ...

Production of sustainable clay bricks using waste fly ash: …

This study was focused on the production of fly ash burnt clay bricks on large scale in the industrial kiln. Section snippets ... Properties of bricks made using fly ash, quarry dust and billet scale. Constr. Build. Mater. (2013) C. Leiva et al. Characteristics of fired bricks with co-combustion fly ashes. J. Build. Eng.

Properties of bricks made using fly ash, quarry dust and billet …

DURABILITY PROPERTY OF FLY ASH, QUARRY DUST AND BILLET SCALE BRICKS. This paper investigates the durability of bricks produced from industrial waste like fly …

Development of unfired bricks using industrial waste

8. LITERATURE REVIEW "Development of Unfired Bricks Using Industrial Waste" Optimization of Process Parameters Chaulia and Das (2008) Optimized the process parameters for fly ash brick …

Properties of bricks made using fly ash, quarry dust and billet …

Abstract. This paper reports the findings of an investigation done on bricks made using fly ash (FA), quarry dust (QD), and billet scale (BS) by non conventional …

10.1016/j.conbuildmat.2012.11.077 | DeepDyve

On the other hand, addition of FA+BS was found to decrease UPV.

(5) The optimum ratio of fly ash and billet scale, quarry dust and billet scale is found to be 1:1 since it showed the best performance with regard to mechanical properties.

(6) Manufacture of bricks using a combination of billet scale, quarry dust and fly ash is …

Effectiveness of industrial waste materials used as ingredients in fly

Performance of bricks made using fly ash and bottom ash. Constr. Build. Mater. ... Properties of bricks made using fly ash, quarry dust and billet scale. Constr. Build. Mater. (2013) Huan-Lin Luo et al. Waste foundry sand reused as clay replacement for tile manufacture ... Manufacturing of sustainable bricks: Utilization of mill scale and ...

Production of eco-friendly hybrid blocks

Valorization of stabilized river sediments in fired clay bricks: factory scale experiment. J. Hazard. Mater. (2009) M. Dondi et al. Recycling PC and TV waste glass in clay bricks and roof tiles. ... Properties of bricks made using fly ash, quarry dust and billet scale, Construction and Building Material Journal, 41. PP. (2013)

10.1016/j.conbuildmat.2012.11.077 | DeepDyve

In series B, the ratio of billet scale and fly ash was increased to 40% and cement and quarry dust were decreased to 10% and 50% respectively to have a better …

Sivakumar Naganathan's LiveDNA Profile

A.Y.O. Mohamed and K.N. Mustapha, 2015. Performance of bricks made using fly ash and bottom ash. Construct. Build. ... S. Naganathan and K. Mustapha, 2014. Effect of quarry dust and billet scale additions on the properties of fly ash bricks. ... 2013. Properties of bricks made using fly ash, quarry dust and billet scale. Constr. Build. …

Performance of bricks made using fly ash and bottom ash

Performance of bricks and brick masonry prism made using coal fly ash and coal bottom ash. S. K. Verma Deepankar Kumar Ashish Joginder Singh. Environmental Science, Engineering. 2016. The major problem of a coal combustion-based power plant is that it creates large quantity of solid wastes.

Strength, durability, thermal and run-off properties of fired clay …

The tile specimens were manufactured in an industrial scale plant by replacing clay with ceramic sludge: 0%, 10%, 15%, 20% and 25% (by weight). ... Properties of bricks made by using fly ash, quarry dust and billet scale. Constr. Build. ... The results presented here can be considered a starting point for the safe removal of spent ...

Experimental investigation on various efficient

This study focuses on vertical strength of AAC block panels and comparesthem with traditional clay bricks and fly ash bricks. The investigation process is done in 2 stages, modeling and estimating the quantity of materials required for a model 10x10 feet wall and determining the characteristics such as durability, space occupancy, …

Use of sugarcane bagasse ash as brick material

The bricks were developed using the quarry dust (QD) as a replacement to natural river sand and lime (L) as a binder. SBA as a principal raw material was characterized using X-ray fluorescence ...

Properties of bricks made using fly ash, quarry dust and billet scale

Results for mechanical properties and durability were rewarding and promising. The optimum ratio of billet scale and fly ash is found to be 1:1, billet scale and quarry dust …

Strength properties of concrete blocks with Sand

It is found to be angular, compared to the rounded cement particles. Expansion of concrete is found to reduce as the percentage of granite powder increased [2]. Finer granite powder improved resistance to chloride ingress while quarry coarser one reduced it. Quarry dust, fly ash and billet scale is used to make bricks.